black bear 84

THE ARC AAA FLASHLIGHT

There is a type of very small LED lights (called key chain light) that is ideal for police officers who have to write a report or a ticket. The light is very flood like and not very powerful at 5.5 lumens, it will not affect night vision much and will illuminate the pad very well if the light is clipped to your hat or epaulet.

The little ARC is small and almost weightless, it measures 2.7” long and 0.5 “in diameter and can last for 5 hours to 50 percent output on a regular AAA battery.
The body of the light is 6061 aluminum with military hard anodized type III and coated with chem-cote in the interior.




Cost of the light is $29.95 for the regular model and $44.95 for the Premium model that has a more powerful LED of 9 lumens.

The light is provided with a clip that will stay very well put on the brim of a hat or cap, it also has a split ring to attach the light to a key chain. Of course it also makes a good light if attached to the bill of a sporting cap when camping.




There are some chores that require that you use your two hands, and the unobtrusive ARC is hardly noticeable until you need it.

As you can see in the picture, I use rechargeable AAA Nimhs as well as AA’s. The new Nimh batteries are really powerful and have lots of capacity, 1,000 mah for the AAA, and 2700 or more for the AA’s. They can be recharged up to 1,000 times which make them a great saving over using alkaline batteries.

Besides, you will be helping the environment as well as your pocket; I highly recommend the new rechargeable Nimh batteries.
Cheers
Black Bear

__________________
Builder of the BOREALIS 1050 lumens flashlight


and www.blackbearflashlights.com

E-Mail admin@blackbearflashlights.com

black bear 84

THE CLASSIC SUREFIRE E1E EXECTUTIVE ELITE
FLASHLIGHT

This light is a beauty, short, light weight, with considerable power and with a decent run time for an incandescent light
In today’s market it is a little obsolete in the power department, as the Fenix line of small pocket/key chain lights put out more lumens and have more features.
Still, the Surefire E1e is the “classic” small light that arrived at a time when 15 lumens was only achieved with big lights using 2D batteries.

The E1e is extremely well made and finished in hard anodized type III in an olive drab finish; it weights 2.20 ounces and has a length of 3.40 inches. The lens is Pyrex and the reflector is stochastic, meaning that is finished with a light stippled pattern that makes the beam free of defects, rings and artifacts.

The light runs on one of the RC123’s batteries with a run time of 1.5 hours, the beam is nice, but will not throw far as the reflector is quite small, and small reflectors produce quite a flood.
The tail cap has three positions: unscrewed a couple of turns it will lock up the light (what is considered a safety position); screwed a little more, will allow activation of the momentary position by pressing the rubber button; screwed further, will activate the light on constant.




The little light charges the battery from the front, that means you have to take the head out to install the battery, as there is not enough room for the battery to enter if you remove the tail cap, as in most other lights.
The 15 lumens lamp is called MN01, and is 15 lumens of course; the MN02 is 25 lumens but it’s used in the E series Surefire that carries two batteries, as is the more powerful 60 lumens MN03.

I see this light as ideal for a woman’s purse or a man’s pocket. Although the retail price is $79 USD the light is so well made that is worth it. Finally, the light sports a clip that can be used to clip it to the edge of a pocket for quick retrieval, or to the bill of a cap if you need to do some chore using two hands.
Cheers

Black Bear

__________________
Builder of the BOREALIS 1050 lumens flashlight


and www.blackbearflashlights.com

E-Mail admin@blackbearflashlights.com

black bear 84

A decent household flashlight for little money, and will save in battery juice.


HUSKY 2D 3 WATT LED FLASHLIGHT


I was at Home Depot and I spied a new light in the flashlight section. The new torch is a HUSKY brand, which is a brand name of Home Depot. I have used some of their inexpensive lights; they are made in China and represent a good value in some models.

The new light uses two D batteries (that are included in the package) and the source of light is a three watt LED. The difference in this torch is that the switch activates three different levels of illumination.
The package lacks any instructions and doesn’t even mention the output of the light or the run time. So I am guessing that the first mode (the first click) is a 12 lumens light, second click at 40 lumens and the last click about 80 lumens.

The idea of having three different levels is good, it will conserve battery juice when you just need a little light for illumination, and at the same time, the other two settings are there for more lumens when you need to reach farther or put out more intensity.
As this thread is all about comparisons, I decided to pit the new HUSKY against a Maglite 2D LED 3 watt that I bought a few months ago. I purchased the Maglite from Wal Mart for $24 USD, but I think that it was on sale at the time, still price wise the two lights. Compare.

The HUSKY is ½” shorter, otherwise they compare physically to each other and they weight the same, although the HUKY have a slightly smaller head.
The outside of the Husky is finished in a slightly duller anodizing than the Maglite; both lights look handsome on the outside.
In the inside the Husky shows the threads of the tail-cap, body and head very rough. Removing the head I found an adequate heat sink, although the mounting of the LED looks a little lousy. I wanted to take a look at the reflector and plastic lens, but it was not possible to remove the bezel despite my superhuman and my weight-lifter friend efforts - the bezel seems to have been super-glued in place.

The tail-cap sports a flimsy lanyard that I will not trust to hold the light for long, and looking inside at the switch, I found it very cheesy looking, more appropriate for a toy than for a flashlight. The little strip of metal where the battery makes contact with the switch, it doesn’t look good either.

The Maglite 2D on the other hand, is a high quality product with butter smooth threads, a switch that will last forever and a lot of well thought-out features (cam action, self cleaning switch, etc).
The Maglite is an American product that should cost much more of what it does now. Old timers may recall that when they first show up in the 1980’s the price tag was $60 USD and that they were selling like hot cakes, the engineering of the Maglite was at that time well above any of the existing lights, including the Kel-Lite.

In the picture you can see the Maglite 2D LED on left, the Husky light in the middle, and the red one on right is a Black Bear 720 lumens, (1 ½ million candlepower) a custom made light that shows how much illumination we can put into a Maglite “host” 2D, with a little ingenuity, and if the people are willing to pay the price of a custom product.




Here are the beam shots for comparison, 35 yards to the fence.

HUSKY 3 watt



MAGLITE 3 watt



BLACK BEAR 720 LUMENS




My impression is that the Maglite has a much better beam, in color rendition and in intensity. Also, I can throw the beam of the Maglite much further than the Husky, even that both lights are 3 watt, the Maglite is better in quality of LED and power.
Granted - the Maglite has a 2” full reflector, while the Husky could be only 1 ¾ “ that could account for the better throw, but the Maglite definitely has a whiter beam and it is more intense.

All the best
Black Bear

__________________
Builder of the BOREALIS 1050 lumens flashlight


and www.blackbearflashlights.com

E-Mail admin@blackbearflashlights.com

black bear 84

SUREFIRE E2e MODIFICATIONS

Judging for the mail I get from people, there is some interest in modifying the E2e (or E2O) for more lumen output.
The standard question is: Do you have any lamp that will make the E2e brighter?

There are two modifications made to the E2e to make it brighter. Both of them involve the P-61 lamp from Surefire, an incandescent lamp that output 120 lumens for 20 minutes.

The NASCAR modification (more properly named This_is_Nascar, for its developer), involves removing the stock reflector from the P-81 lamp and using the head and reflector of the standard E2e.

On top is the E to C adaptor model, below is the NASCAR model.




And this is the E to C adaptor on top and below the NASCAR modification.




It is necessary to stretch the bezel of the E2e to accommodate the longer P-61 lamp. This is accomplished by installing an O ring between the head and bezel and using a thinner mineral crystal instead of the Pyrex lens.
A washer is also used to bring the lamp to the proper focal point in the reflector. This modification has a run time of seven minutes, when the heat of running the 120 lumen lamp will reach the batteries, causing them to kick the thermal protection. This stops the juice to the lamp. Of course, after the batteries cool down, the light can be used again.

This happens because of the little mass of metal at the head and reflector. If there was more mass of metal at this point the heat would be absorbed (and displaced forward as infrared) and the batteries would continue to provide the full run time of twenty minutes.

And it is here where the second modification makes its appearance; by using an adaptor to bridge the gap between the E series body and a C series head. It is possible to use the P-61 lamp without removing the reflector. All the mass of the adaptor, coupled with the bigger head and the mass of the reflector, perfectly handles the heat of the powerful P-61 lamp, and the full run time of twenty minutes can be achieved, as well as less heat in the part of the light that is held by your hand.

There are a couple of versions in the market of this E to C adaptor. The one shown here was made by Doug Speck in Toronto, Canada. It is hard anodized to match the body of the E2e (or E2O) and the Z-44 (The head of the Surefire Centurion II).
Also, as the reflector (and head) are bigger, the range (throw) is increased over the smaller reflector of the stock E2e. Not to mention changing lamps is a breeze.
For more run time, the P-60 lamp (65 lumens) can be substituted; it will give the light one hour run time with much better throw than the stock E2e.

The NASCAR version has some use when somebody desires a rifle light in the smaller format with an intensity of 120 “real” lumens, and a good flood coverage for clearing rooms. Using a 1” scope ring and a plastic bushing, it is possible to mount the light to any Picattiny or Weaver base.

Best regards,
Black Bear

__________________
Builder of the BOREALIS 1050 lumens flashlight


and www.blackbearflashlights.com

E-Mail admin@blackbearflashlights.com

black bear 84

Q-BEAM MAX MILLION II
TWO MILLION CANDLEPOWER
SPOTLIGHT

I very recently bought a new Q-Beam two million candlepower spotlight. I am a big user of spotlights, in my case I use them to give demonstration of the power of the Borealis 1050 lumens flashlight, in police reunions, night shots, and seminars.

When my eight month-old battery for my two million candlepower Optronics spotlight gave up the ghost, I had to get a new spotlight.
I spied the Q-Beam at Wal-Mart and I bought it on the spot. It is a large spotlight with a four-and-three-quarters inch reflector, and with some extra features not available in other spotlights.

For starters, it comes with two removable batteries. One battery could be on the light while the other is charging, a good feature. Unfortunately, in my case, one of the batteries was already dead and is not recharging. I will have to return the unit and get another, hoping for better luck.

However, bad batteries are nothing new in big spotlights. It seems that the Chinese haven’t gotten the hang of making lead acid batteries last any decent amount of time. I know; I have the corpses of seven spotlights to prove it (some day I will get around to rounding them up and take a picture of them).

I can safely say that I have tried all of them, and I can tell you that a quality spotlight is not available in the USA, unless you buy one of the Australian’s Night Force spotlights. Australians, with their liberal night hunting laws, know a thing or two more about night hunting and lights that the average American hunter does.

For law enforcement the panorama is different. With the advent of the Borealis 1050 lumens flashlight (12 ½” long, 28 oz) a spotlight in the cruiser is no longer needed.

After all, spotlight use for law enforcement is confined to operation from the car, which is why you don’t see a trooper conducting a traffic stop with spotlight in hand or chasing down a suspect with one in tow.

Coming back to the Q-Beam Max Million II, it also has another feature that was not available before in any other spotlight; a double trigger that when touched high, can activate mechanically a spring that will push the smaller part of the two-part reflector/ bulb holder, forward. This causes the focus to change to a wider flood; interesting concept, but perhaps of dubious utility. I have seen it employed in flashlights before, but by the use of two filaments positioned in the bulb envelope at different heights.

Here is a picture of the Q-Beam together with the Borealis



Unfortunately the Achilles’ heel of any spotlight is the quality of its batteries. In the normal use that I give them, they never last more than 6 to 8 months, which is why I am not looking to pay more than half a century note for one, with is just what the new Q-Beam cost me at Wal-Mart.

How does it compare with the Borealis 1050 lumens (two million candlepower)?
To answer that question, I move them to the backyard of my local church, where I have a solid wall of trees and a range of 35 yards (I try to avoid solid light-painted walls that produce too much reflection and confuse the camera).

Q-Beam Max II Spotlight



Borealis 1050 lumens flashlight




Black Bear 720 lumens flashlight





The new Spotlight did well in comparison, but it is more inside the range of the Black Bear 720 lumens (10 “ long 23 oz) than of the more powerful Borealis. Here are the pictures for you to judge; of course the Borealis and the BB 720 are better law enforcement tools as the side spill is bigger and the intensity and the color are brighter. Of course, you need side spill to avoid panning a tight focus’ light and losing precious seconds when clearing a room or warehouse.
For those that use the Q-Beam for varmint shooting (with a partner to hold the light of course) the light will do okay up to 300 yards.

For that use you can take advantage of the red filter (at shorter distance) and the other two filters, ( blue and amber), are completely useless for varmint shooting and for any other use I can imagine, as I can not see a blood tracker using such a big spotlight with the blue filter on it.

Respectfully,
Black Bear

__________________
Builder of the BOREALIS 1050 lumens flashlight


and www.blackbearflashlights.com

E-Mail admin@blackbearflashlights.com